|
CAS
# 7664-93-9 SULFURIC ACID EXTRA PURE |
|||
|
Blulux Laboratories Pvt. Ltd |
|
|
|
HAZARD IDENTIFICATION
==============================================================================
Route Of Entry Inds - Inhalation: YES Skin: YES Ingestion: YES
Carcinogenicity Inds - NTP: NO IARC: YES OSHA: NO
Health Hazards Acute And Chronic: ACUTE:EXPOS TO VAPS MAY CAUSE PULM IRRIT
& INFLAMM, COUGH, PULM EDEMA & EYE IRRIT. SEV CHEM BURNS TO EYES &
SKIN. SEVERITY OF BURN IS GENRLY DETERM AT CONC OF SOLN & DURATION OF
EXPOS. SKIN CONT:CONT OF UNDILUTED PROD W/SKIN OR EYES QUICKLY CAUSES SEV IRRIT
& PAIN & MAY CAUSE BURNS, NECROSIS & PERM (EFTS OF OVEREXP)
Explanation of Carcinogenicity: SULFURIC ACID:IARC MONOGRAPHS, VOL 54, PG 41,
1992:GROUP 1. ANIMAL:PULMONARY IRRITANT.
Signs and Symptoms of Overexposure: HLTH HAZ:INJURY. FOR DILUTE
SOLNS:PRLNG/RPTD CONT MAY CAUSE DRYING, CRACKING/IRRIT. EYE CONT:CONT OF LIQ
WILL CAUSE SEV BURNS. MAY RSLT IN PERM IMPAIRMENT OF VISION, EVEN BLINDNESS.
INHAL:MISTS & VAPS MAY CAUSE SEV IRRIT TO RESP TRACT. INGE ST:CAN CAUSE SEV
BURNING & PAIN IN LIPS, MOUTH, TONGUE, THROAT & STOM. (ING 3)
Medical Conditions Aggravated by Overexposure: MAY AGGRAVATE EXISTING
DERMATITIS, ASTHMA & INFLAMMATORY OR FIBROTIC PULMONARY DISEASE.
==============================================================================
FIRST AID
==============================================================================
INHAL:YOU MAY HAVE 10 SECS/LESS TO AVOID SERIOUS PERM INJURY. REMOVE TO FRESH
AIR. IF BRTHG HAS STOPPED, ADMIN ARTF RESP & SEEK MED ATTN. SKIN:REMOVE
CONTAM CLTHG & RINSE SKIN W/WATER FOR 15 MINS. GET IMMED MED ATTN. MOVING
VICTIM FROM WATE R ACCESS FOR TRANSPORT TO MED AID SHOULD BE DONE ONLY ON
ADVICE OF QUALIFIED MED PERS. WASH CONTAM CLTHG THORO BEFORE RE-USE. DISCARD
CONTAM SHOES. (ING 8)
==============================================================================
FIRE FIGHTING MEASURES
==============================================================================
Flash Point Text: NOT APPLICABLE
Auto Ignition Temperature Text:
Lower Limits: N/A Upper Limits: N/A
Extinguishing Media: SUITABLE FOR SURROUNDING FIRE. CARBON DIOXIDE, DRY
CHEMICAL, FOAM.
Fire Fighting Procedures: USE NIOSH APPRVD SCBA & FULL PROT EQUIP (FP N).
USE WATER ON COMBUST BURNING IN VICIN OF THIS MATL BUT USE CARE AS WATER
APPLIED DIRECTLY TO ACID CAUSES(SUPDAT)
Unusal Fire/Explosion Hazard: EVOLUTION OF EXPLO HYDROGEN GAS ON CONT W/MOST
METALS. TOXIC GASES (SULPHURIC ACID FUMES, SULFUR DIOXIDE & CARBON
MONOXIDE) MAY BE RELS DUE TO THERMAL DECOMP.
==============================================================================
RELEASE MEASURES
==============================================================================
Spill Release Procedures: NOTIFY FIRE & ENVIRON AUTHS. UTILIZE FULL PROT
CLTHG, INCL BOOTS & NIOSH APPRVD SCBA. CNTN SPILL IN ORDER TO PVNT CONTAM
OF SEWAGE SYS/WATERWAY. REMOVE ALL SOURCES OF IGNIT. IF POSS NEUT ON DRY BASIS
W/SUITABLE ALKALI SUCH AS LIME, SODA ASH / (ING 13)
Neutralizing Agent: ALKALI SUCH AS LIME, SODA ASH OR SODIUM BICARBONATE.
Waste Disposal Methods: DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL
REGULATIONS (FP N). DISPOSAL I/A/W MUNICIPAL, PROVINCIAL & FEDERAL
REGULATIONS.
==============================================================================
HANDLING AND STORAGE
==============================================================================
KEEP AWAY FROM HEAT, SPARKS & OPEN FLAMES. PROTECT CNTNR FROM PHYSICAL DMG.
KEEP CNTNR CLSD WHEN NOT IN USE. STORE AWAY FROM INCOMPATIBLE MATLS.
==============================================================================
EXPOSURE CONTROLS/PERSONAL PROTECTION
==============================================================================
Respiratory Protection: USE NIOSH APPROVED RESPIRATOR.
Ventilation: VENTILATE ADEQUATELY.
Protective Gloves: PVC OR NEOPRENE GLOVES.
Eye Protection: ANSI APPRVD CHEM WORKERS GOGGS &(SUPDAT)
Other Equipment: ANSI APPROVED EYE WASH FOUNTAIN & DELUGE SHOWER (FP N).
ALWAYS WEAR IMPERVIOUS PROTECTIVE CLOTHING. BOOTS.
Work Hygenic Practices: ANSI APPROVED EYE WASH FOUNTAIN & DELUGE SHOWER (FP
N). ALWAYS WEAR IMPERVIOUS PROTECTIVE CLOTHING. BOOTS.
Supplemental Safety & Health: BP:93.19%-549F,287C; 96%-606F,319C;
98%-633F,334C; 100%-525F;274C. SPEC GRAV(H*2O=1):93.19%-1.8354; 96%-1.8427;
98%-1.8437; 100%-1.8391. FIRE FIGHT PROC:SPATTERING OF ACID. CNDTNS
(STAB):AVOID EXCESSIVE HEAT, SPKS & OPEN FLAME. OTHER PREC:R ESIDUE/VAP.
EYE PROT:FULL LGTH FSHLD (FP N). MATLS TO AVOID:HYDROXIDES, (ING 2)
==============================================================================
PHYSICAL AND CHEMICAL PROPERTIES
==============================================================================
Boiling Point:
SUPP DATA
Melting/Freezing Point:
N/K
Decomposition Temp:
N/K
Vapor Pressure: 0.0018 Vapor Density: 3.4
Specific Gravity: SUPP DATA
PH: <1
Viscosity: N/P
Evaporation Rate & Reference: NOT APPLICABLE
Solubility in Water: MISCIBLE
Appearance and Odor: LIQUID; NO ODOR.
Percent Volatiles by Volume: N/K
Corrosion Rate: N/K
==============================================================================
STABILITY AND REACTIVITY
==============================================================================
Stability Indicator: YES
Stability Conditions to Avoid: CONCENTRATED ACID IS STRONG OXIDIZING AGENT. MAY
CAUSE IGNIT OF COMBUST MATL ON CONT W/GENERATION OF TOX FUMES. (SUPDAT)
Materials to Avoid: HIGHLY REACTIVE W/MANY MATLS INCL WATER, METALS, METAL
OXIDES, CARBIDES, CHLORATES, PICRATES, NITRATES, (SUPP DATA)
Hazardous Decomposition Products: SULPHURIC ACID DECOMPOSITION MAY RESULT IN
RELEASE OF TOX GASES (SULPHURIC ACID FUMES, SULPHUR DIOXIDE, CARBON MONOXIDE.
Hazardous Polymerization Products: NO
Conditions to Avoid Polymerization: NOT RELEVANT
==============================================================================
TOXICOLOGICAL
==============================================================================
N/P
==============================================================================
ECOLOGICAL
==============================================================================
N/P
==============================================================================
DISPOSAL
==============================================================================
DISPOSAL MUST BE I/A/W FEDERAL, STATE & LOCAL REGULATIONS (FP N). DISPOSAL
I/A/W MUNICIPAL, PROVINCIAL & FEDERAL REGULATIONS.
==============================================================================
TRANSPORTATION
==============================================================================
N/P
==============================================================================
REGULATORY
==============================================================================
SARA Title III: N/P
Federal Regulatory: N/P
==============================================================================
OTHER
==============================================================================
|
|
|
Mfgs. & Exporters: Laboratory Reagents, Fine Chemicals,
Analytical Reagents & Dehydrated Culture Media |
|
|
|
|
